Start Submission Become a Reviewer

Reading: Distribution of the vibration effect within the stacked boxes during vehicular road transpor...

Download

A- A+
dyslexia friendly

Articles

Distribution of the vibration effect within the stacked boxes during vehicular road transportation of tomatoes

Authors:

C. L. Ranatunga ,

University of Sri Jayewardenepura, Nugegoda, LK
About C. L.
Dept of Physics, Faculty of Applied Sciences
X close

H. H. E. Jayaweera,

University of Colombo, Colombo 03, LK
About H. H. E.
Centre for Instrument Development, Department of Physics, Faculty of Science
X close

S. K. K. Suraweera,

University of Colombo, Colombo 03, LK
About S. K. K.
Centre for Instrument Development, Department of Physics, Faculty of Science
X close

T. R. Ariyaratne

University of Colombo, Colombo 03, LK
About T. R.
Centre for Instrument Development, Department of Physics, Faculty of Science
X close

Abstract

Parameters of the Road-Vehicle-Load system influence the vibration effects generated at vehicular road transportation. Vertical vibration acceleration (PSDmax) experienced by the tomato boxes and tomatoes within the box was studied using the popular transport means in Illukkumbura area in Matale. The road quality was estimated using the International Road Roughness Index (IRI). Fully loaded Mitsubishi Canter truck at an average speed of 20 kmh-1 on a road rated at IRI between 2 to 3.5 mm/m registered increasing trend in the PSD of vibration from the front side towards the rear side of the truck in the horizontal direction. The observed average PSD values are in the approximate ratio, front : middle : rear ≈ 1 : 3: 6. Also the PSD of the vibration was found to be amplified from the bottom stack towards the topmost stack in the vertical direction. The observed average PSD values at 1st, 2nd, 3rd, and 4th stacks are in the approximate ratio, 1 : 1 : 1.5 : 2.5. PSD of vibration was studied with a fully loaded truck at different speeds on a road consisting of segments rated at varying IRI. The fully loaded truck at different speeds on a road consisting of segments rated at varying IRI registered varying PSD values of vibration. Even at lower speeds such as 25 kmh-1 the vibration acceleration produced at “poor” quality (IRI > 5 mm/m) roads was nearly 4 times higher compared to that produced at “fair” (IRI 2 to 3.5 mm/m) or “good” quality (IRI 0.9 to 2 mm/m) roads. Registered pattern of the PSD appears to be similar at the tomato boxes and at the tomatoes within the same box.
How to Cite: Ranatunga, C.L. et al., (2016). Distribution of the vibration effect within the stacked boxes during vehicular road transportation of tomatoes. Vidyodaya Journal of Science. 19, pp.23–31.
Published on 11 Jul 2016.
Peer Reviewed

Downloads

  • PDF (EN)

    comments powered by Disqus